|
Back to Data Sheets
CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
Klein Catalog # 51138
BP702 RTV Clear
Revision Date: 8/12/98
MANUFACTURER/SUPPLIER'S/NAME:
Aerosol Systems, 9150
Valley View Road, Macedonia, OH 44056 (330) 467-4195
COMPOSITION/INFORMATION ON INGREDIENTS
PRODUCT COMPOSITION/
ACGIH TLV OSHA PEL
CAS REG NO. WGT. % TWA STEL TWA STEL UNITS
Dimethylsiloxane
70131-67-8
80-90
N/A
N/A
N/A
N/A
N/A
Amorphous Silica
7631-86-9
5-15
10 mg/m3
N/A
15 mg/m3
N/A
mg/m3
Ethyltriacetoxysilane
17689-77-9
1-10
See Below
See Below
See Below
See Below
N/A
Methyletriacetoxysilane
4253-34-3
1-10
See Below
See Below
See Below
See Below
N/A
Polydimethylsiloxane
63148-62-9
1-10
N/A
N/A
N/A
N/A
N/A
Additional Component Information:
Observe limits for Acetic Acid formed during
curing upon exposure to water and humid air. OSHA PEL - TWA 10ppm,
ACGIH TLV - TWA 10 ppm, STEL - 15 ppm. Outer compartment contains
a flammable hydrocarbon propellant (Propane/Isobutane/n-Butane
blend).
HAZARDS IDENTIFICATION
HEALTH HAZARD DATA (ACUTE AND CHRONIC)
No injury from silica
dust should occur during reasonable use. If use creates respirable
particles, some respiratory systems injury may occur. This product,
as with any chemical, may enhance allergic conditionsin certain
people. No known chronic health effects, but unnecessary exposure
to any chemical should be avoided. Cured sealant is nonhazardous.
OTHER:
None.
CARCINOGENICITY:
NA
FIRST AID
Flush eyes and skin
with water for 15 minutes. Remove to fresh air.
ROUTES OF ENTRY
Ingestion Inhalation
Skin
SIGNS AND SYMPTOMS OF OVEREXPOSURE_
Swallowing large amounts
may cause digestive discomfort. Vapor overexposure may irritate
nose, throat, and eyes seriously with moderate corneal injury
and considerable redness lasting a week or more.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE:_
None known
PHYSICAL AND CHEMICAL PROPERTIES
Boiling Point N/A
Vapor Pressure at
70F 66
VAPOR DENSITY (AIR=1)
>1
EVAP. RATE(BUTYL
ACETATE=1) <1
SPECIFIC GRAVITY
(WATER=1) The ratio of the weight of a volume of material to the
weight of an equal volume of water. Usually expressed as greater
than one (>1).
1.04
Solubility Nil
Appearance Clear
Odor Slightly Medicinal
PH: Not Applicable
STABILITY AND REACTIVITY
STABILITY: STABLE
INCOMPATIBILITY:- Strong oxidizers
Water causes curing.
HAZARDOUS THERMAL
DECOMPOSITION/COMBUSTION PRODUCTS:- Acetic acid. Carbon dioxide.
Silicon dioxide.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR
REGULATORY INFORMATION
CALIFORNIA PROPOSITION
65:
NONE
Ozone Depleting
Substances:
None
HMIS:
FLAMMABILITY 1 , REACTIVITY 0 , HEALTH 1
NFPA:
FLAMMABILITY 1 , REACTIVITY 0 , HEALTH 1
SARA 313 TITLE III
- TOXIC CHEMICALS LIST:
None
DOT Shipping Name:
Consumer Commodity, ORM-D
CONTROL MEASURES
Respiratory Protection Equipment
Use NIOSH approved respirator if TLV limit is
exceeded.
VENTILATION:
Local exhaust - yes
PROTECTIVE GLOVES:
None required if spraying.
EYE AND FACE PROTECTION:
Safety glasses.
OTHER PROTECTIVE EQUIPMENT:
Long pants Long sleeves
SAFE HANDLING
Do not smoke while using. Wash hands after use.
PRECAUTIONS FOR SAFE HANDLING AND USE
Flash Point 212F T C C
LOWER EXPLOSION
LIMIT :
ND
UPPER EXPLOSION
LIMIT :
ND
EXTINGUISHING MEDIA:-
Water fog, carbon dioxide, foam, dry
chemical
UNUSUAL FIRE AND
EXPLOSION HAZARDS:-
Heated cans may burst. SiO2, CO2
SPECIAL FIRE FIGHTING
PROCEDURES
Keep containers cool. Use equipment
or shielding required to protect against bursting or venting containers.
SPILL PROCEDURES:_ Remove product
and contain for salvage disposal.
WASTE DISPOSAL METHODS:_
Dispose in accordance with Federal,
State and Local regulations.
PRECAUTIONS TO BE
TAKEN IN HANDLING AND STORAGE: This section contains precautions
for general handling and storage of this particular material.
This section is generally for SPBD customers; although the statements
should generally apply for internal use as well. Any in-plant
rules or procedures should take priority over these handling and
storage precautions.
Keep away from heat, sparks, or open
flame. Store at temperatures below 120F.
OTHER INFORMATION: When spraying
more than one half can continuously or more than one can consecutively,
use NIOSH approved respirator.
NFPA 30B Level:
1
Back to Data Sheets |
